Draw-tite 24886 SPORTFRAME HITCH Bedienungsanleitung PDF herunterladen

Installation Instructions

Subaru Impreza 5-Dr. Wagon

Including older Outback Sport & WRX

(Will not fit vehicles with quad exhaust outlets)

Subaru XV Crosstrek

Part Numbers:

60303

24886

77274

Hitch Shown In Proper Position

Wiring Access Location: PC3, PC4

Equipment Required: Metal File

Wrenches: 3/4”

Drill Bits: 1/2”, 3/8”

1. Lower exhaust by disconnecting rubber exhaust hangers from hanger brackets, 2 each side.

2. Remove plastic plugs from existing holes in frame rails and discard.

3. Use 3/8” drill and file to modify forwardmost hole in each frame rail, as shown in Figure 2, to allow fishwiring of spacers and carriage bolts.

4. Use ½” drill bit to enlarge rearmost hole in frame rail, both sides

5. Fishwire spacer and carriage bolt thru access hole modified in step 3 and down thru rearmost hole in each frame rail (see figure 3). Insert

remaining blocks and carriage bolts into access holes and drop back down thru holes, making sure blocks span both sides of hole (see figure

4).

6. Raise hitch into position, with ¼ x1/1/2 x 2 spacer between frame and hitch bracket at forward attachment as shown, being careful not to push

fasteners into frame, and secure with conical washers and nuts. Tighten ½-13 GR5 fasteners to 75 lb.-ft. (102 N*M)

7. Raise exhaust back into position and reattach exhaust hangers disconnected in step 1.

z 2012 Cequent Performance Products, Inc.

Sheet 1 of 3 24886N 11/14/12 Rev. B

Qty. (4) Carriage Bolt – ½-13 x 1.75 GR5

Qty. (4) Hex Nut – ½-13

Qty. (4) Spacer – ¼ x 1 x 3 (Square hole)

Qty. (2) Spacer – ¼ x 1-1/2 x 2

Qty. (4) Conical Washer – ½”

Qty. (2) Pull wire – ½”

Tighten all ½-13 GR5 fasteners with torque wrench to 75 Lb.-Ft. (102 N*M)

Note: check hitch frequently, making sure all fasteners and ball are properly tightened. If hitch is removed, plug all holes in trunk pan or other body panels to prevent

entry of water and exhaust fumes. A hitch or ball which has been damaged should be removed and replaced. Observe safety precautions when working beneath a

vehicle and wear eye protection. Do not cut access or attachment holes with a torch.

This product complies with safety specifications and requirements for connecting devices and towing systems of the state of New York, V.E.S.C. Regulation V-5 and

SAE J684.

2000 LB (908 Kg) Max Gross Trailer Weight

200 LB (90.8 Kg) Max Tongue Weight

Do Not Exceed Lower of Towing Vehicle

Manufacturer’s Rating or

Drawbar must be used in the

RISE position only.

Drawbar Kit:

3593

Fastener Kit: 24886F

Remove plastic plugs

From existing holes

Both sides

Spacer between frame and

Hitch bracket - typical

3/8” dia. Drilled holes

Figure 2

Access hole modification to allow

fishwiring of block and carriage bolt

Enlarge to 1/2” - typical

Both sides

Modify this hole - both

sides to allow fishwiring-

See figure 2

Figure 3

Kink pull wire to keep

Spacer independent of bolt

Existing 7/8”

Diameter hole

in frame

Fascia

A. Insert bolt and

Block into frame

B. Align block on

access hole

C. Pull bolt thru

block

Figure 4

Fishwiring Procedure

24810 UHaul

Accessory Rating

Form F206 Rev B 9-17-2012

1 2 3

Inhaltsverzeichnis

Seite 1 - Installation Instructions

Installation Instructions Subaru Impreza 5-Dr. Wagon Including older Outback Sport & WRX (Will not fit vehicles with quad exhaust outlets) Sub

Seite 2 - Instructions d’installation

Instructions d’installation Subaru Impreza 5-Dr. Wagon y compris ancien Outback Sport et WRX Numéros de pièces : 60303 24886 77274 Attelage montré

Seite 3 - 24810 UHaul

Instrucciones de instalación Subaru Impreza 2.5i 5-Dr. Wagon Incluye más viejo Outback Sport y WRX Números de partes: 60303 24886 77274 El enganche s

Kommentare zu diesen Handbüchern

Keine Kommentare

Draw-tite 24886 SPORTFRAME HITCH Bedienungsanleitung

Stöbern Sie online oder laden Sie Bedienungsanleitung nach Für das Auto Draw-tite 24886 SPORTFRAME HITCH herunter. Draw-Tite 24886 SPORTFRAME HITCH User Manual Benutzerhandbuch

Inhaltsverzeichnis

Kommentare zu diesen Handbüchern

Verwandte Produkte und Handbücher für Für das Auto Draw-tite 24886 SPORTFRAME HITCH